Article Sidebar

Download
PDF
Statistic
Read Counter : 1810 Download : 583

Downloads

Download data is not yet available.

Main Article Content

Abstract

Compressed natural gas (CNG) is a popular alternative fuel because of its more environmentally friendly properties than fossil fuels , including applications in diesel engines. However, supplying too much compressed natural gas fuel causes poor engine performance and emissions due to a decrease in the air-fuel ratio on the dual-fuel engine. The addition of air using electric superchargers was done to return the air-fuel ratio to ideal conditions. Lambda value (λ) was variation under low load (1.52 to 2.71), medium load (1.18 to 2.17), and high load (0.94 to 2.17) on a CNG-diesel dual fuel engine. The addition of pure air in each load can increase combustion stability in certain lambda, which was indicated by an increase in thermal efficiency, heat release rate, and a decrease in ignition delay, combustion duration, hydrocarbon, and carbon monoxide emissions.

Keywords

CNG Engine performance Emission Air fuel ratio Thermal efficiency

Article Details

Creative Commons License

This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

References

  1. T. Kivevele, T. Raja, V. Pirouzfar, B. Waluyo, and M. Setiyo, “LPG-Fueled Vehicles: An Overview of Technology and Market Trend,” Automotive Experiences, vol. 3, no. 1, pp. 6–19, 2020, doi: 10.31603/ae.v3i1.3334.
  2. H. Li, S. You, H. Zhang, W. Zheng, and L. Zou, “Analysis of the impacts of heating emissions on the environment and human health in North China,” Journal of cleaner production, vol. 207, pp. 728–742, 2019.
  3. W. Austin, G. Heutel, and D. Kreisman, “School bus emissions, student health and academic performance,” Economics of Education Review, vol. 70, pp. 109–126, 2019.
  4. I. Veza et al., “Strategies to achieve controlled auto-ignition (CAI) combustion: A review,” Mechanical Engineering for Society and Industry, vol. 3, no. 1, pp. 22–34, 2023.
  5. M. Mofijur, M. Rasul, N. M. S. Hassan, and M. N. Uddin, “Investigation of exhaust emissions from a stationary diesel engine fuelled with biodiesel,” Energy Procedia, vol. 160, pp. 791–797, 2019.
  6. J. B. Heywood, “Combustion engine fundamentals,” 1a Edição. Estados Unidos, 1988.
  7. S. Ozer, M. Akçay, B. Doğan, D. Erol, and M. Setiyo, “The Effects of Canola Oil/Diesel Fuel/Ethanol/N-Butanol/Butyl Di Glycol Fuel Mixtures on Combustion, Exhaust Gas Emissions and Exergy Analysis,” Automotive Experiences, vol. 5, no. 3, pp. 268–287, 2022.
  8. A. Sule, Z. A. Latiff, M. A. Abbas, I. Veza, and A. C. Opia, “Recent Advances in Diesel-Biodiesel Blended with Nano-Additive as Fuel in Diesel Engines: A Detailed Review,” Automotive Experiences, vol. 5, no. 2, pp. 182–216, 2022, doi: 10.31603/ae.6352.
  9. A. Bhikuning, “The simulation of performance and emissions from rapeseed and soybean methyl ester in different injection pressures,” Automotive Experiences, vol. 4, no. 3, pp. 112–118, 2021.
  10. R. Rosid, B. Sudarmanta, L. Atmaja, and S. Özer, “An Experimental Study of the Addition of Air Mass Flow Rate Using a 30% Emulsion-Fueled Diesel Engine at High Load,” Automotive Experiences, vol. 3, no. 2, 2020.
  11. M. Setiyo, D. Yuvenda, and O. D. Samuel, “The Concise Latest Report on the Advantages and Disadvantages of Pure Biodiesel (B100) on Engine Performance: Literature Review and Bibliometric Analysis,” Indonesian Journal of Science and Technology, vol. 6, no. 3, pp. 469–490, 2021, doi: 10.17509/ijost.v6i3.38430.
  12. S. Saravanan, “Effect of exhaust gas recirculation (EGR) on performance and emissions of a constant speed DI diesel engine fueled with pentanol/diesel blends,” Fuel, vol. 160, pp. 217–226, 2015.
  13. S. Zhu et al., “A review of water injection applied on the internal combustion engine,” Energy conversion and management, vol. 184, pp. 139–158, 2019.
  14. W. Zhang, S. Chang, W. Wu, L. Dong, Z. Chen, and G. Chen, “A diesel/natural gas dual fuel mechanism constructed to reveal combustion and emission characteristics,” Energy, vol. 179, pp. 59–75, 2019.
  15. M. Feroskhan, S. Ismail, M. G. Reddy, and A. S. Teja, “Effects of charge preheating on the performance of a biogas-diesel dual fuel CI engine,” Engineering Science and Technology, an International Journal, vol. 21, no. 3, pp. 330–337, 2018.
  16. K. Nithyanandan, Y. Lin, R. Donahue, X. Meng, J. Zhang, and F. L. Chia-fon, “Characterization of soot from diesel-CNG dual-fuel combustion in a CI engine,” Fuel, vol. 184, pp. 145–152, 2016.
  17. N. N. Mustafi, R. R. Raine, and S. Verhelst, “Combustion and emissions characteristics of a dual fuel engine operated on alternative gaseous fuels,” Fuel, vol. 109, pp. 669–678, 2013.
  18. R. G. Papagiannakis and D. T. Hountalas, “Combustion and exhaust emission characteristics of a dual fuel compression ignition engine operated with pilot diesel fuel and natural gas,” Energy conversion and management, vol. 45, no. 18–19, pp. 2971–2987, 2004.
  19. R. M. Susanto and M. Setiyo, “Natural Gas Vehicle (NGV) : Status Teknologi dan Peluang Status Teknologi dan Peluang Pengembangannya,” Automotive Experiences, vol. 1, no. 01, pp. 1–6, 2018, doi: https://doi.org/10.31603/ae.v1i01.2000.
  20. M. Y. E. Selim, “Sensitivity of dual fuel engine combustion and knocking limits to gaseous fuel composition,” Energy Conversion and Management, vol. 45, no. 3, pp. 411–425, 2004.
  21. W. W. Purwanto, Y. Muharam, Y. W. Pratama, D. Hartono, H. Soedirman, and R. Anindhito, “Status and outlook of natural gas industry development in Indonesia,” Journal of Natural Gas Science and Engineering, vol. 29, pp. 55–65, 2016, doi: 10.1016/j.jngse.2015.12.053.
  22. M. Setiyo, “Alternative fuels for transportation sector in Indonesia,” Mechanical Engineering for Society and Industry, vol. 2, no. 1, pp. 1–6, 2022, doi: 10.31603/mesi.6850.
  23. S. Munahar, M. Setiyo, M. M. Saudi, A. Ahmad, and D. Yuvenda, “Modelling Fuel Cut Off Controller on CNG Engines Using Fuzzy Logic: A Prototype,” International Journal on Advanced Science, Engineering and Information Technology, vol. 12, no. 5, pp. 1857–1865, 2022, doi: 10.18517/ijaseit.12.5.16849.
  24. B. Sudarmanta, A. Setiyawan, A. B. K. Putra, D. Yuvenda, and J. D. Silva, “Optimization of pilot diesel injection timing on load variation dual fuel diesel-CNG engine on combustions and emissions characteristics,” Int Rev. Mech Eng, vol. 13, 2019.
  25. N. S. Octaviani and M. B. Zaman, “The implementation of CNG as an alternative fuel on marine diesel engine,” International Journal of Mechanical Engineering and Technology, vol. 9, no. 13, pp. 24–33, 2018.
  26. M. Y. E. Selim, “Pressure–time characteristics in diesel engine fueled with natural gas,” Renewable energy, vol. 22, no. 4, pp. 473–489, 2001.
  27. B. Yang and K. Zeng, “Effects of natural gas injection timing and split pilot fuel injection strategy on the combustion performance and emissions in a dual-fuel engine fueled with diesel and natural gas,” Energy conversion and management, vol. 168, pp. 162–169, 2018.
  28. M. Xu, W. Cheng, H. Zhang, T. An, and S. Zhang, “Effect of diesel pre-injection timing on combustion and emission characteristics of compression ignited natural gas engine,” Energy Conversion and Management, vol. 117, pp. 86–94, 2016, doi: 10.1016/j.enconman.2016.02.054.
  29. R. G. Papagiannakis, D. T. Hountalas, and C. D. Rakopoulos, “Theoretical study of the effects of pilot fuel quantity and its injection timing on the performance and emissions of a dual fuel diesel engine,” Energy Conversion and Management, vol. 48, no. 11, pp. 2951–2961, 2007.
  30. S. R. Turns, An introduction to combustion: concepts and applications, 3rd Editio. New York: McGraw-Hill Co, 2012.
  31. B. B. Sahoo, N. Sahoo, and U. K. Saha, “Effect of engine parameters and type of gaseous fuel on the performance of dual-fuel gas diesel engines—A critical review,” Renewable and Sustainable Energy Reviews, vol. 13, no. 6–7, pp. 1151–1184, 2009.
  32. B. Yang, L. Ning, W. Chen, B. Wang, K. Zeng, and W. Dong, “Parametric investigation the particle number and mass distributions characteristics in a diesel/natural gas dual-fuel engine,” Applied Thermal Engineering, vol. 127, pp. 402–408, 2017.
  33. S. Verma, L. M. Das, S. S. Bhatti, and S. C. Kaushik, “A comparative exergetic performance and emission analysis of pilot diesel dual-fuel engine with biogas, CNG and hydrogen as main fuels,” Energy Conversion and Management, vol. 151, pp. 764–777, 2017.
  34. R. G. Papagiannakis, C. D. Rakopoulos, D. T. Hountalas, and D. C. Rakopoulos, “Emission characteristics of high speed, dual fuel, compression ignition engine operating in a wide range of natural gas/diesel fuel proportions,” Fuel, vol. 89, no. 7, pp. 1397–1406, 2010.
  35. M. Ehsan and S. Bhuiyan, “Dual fuel performance of a small diesel engine for applications with less frequent load variations,” International Journal of Mechanical and Mechatronics Engineering, vol. 9, no. 10, pp. 30–39, 2009.
  36. K. Cheenkachorn, C. Poompipatpong, and C. G. Ho, “Performance and emissions of a heavy-duty diesel engine fuelled with diesel and LNG (liquid natural gas),” Energy, vol. 53, pp. 52–57, 2013.
  37. S. Imran, D. R. Emberson, A. Diez, D. S. Wen, R. J. Crookes, and T. Korakianitis, “Natural gas fueled compression ignition engine performance and emissions maps with diesel and RME pilot fuels,” Applied Energy, vol. 124, pp. 354–365, 2014.
  38. L. Tarabet, K. Loubar, M. S. Lounici, K. Khiari, T. Belmrabet, and M. Tazerout, “Experimental investigation of DI diesel engine operating with eucalyptus biodiesel/natural gas under dual fuel mode,” Fuel, vol. 133, pp. 129–138, 2014.
  39. S. S. Kalsi and K. A. Subramanian, “Experimental investigations of effects of EGR on performance and emissions characteristics of CNG fueled reactivity controlled compression ignition (RCCI) engine,” Energy Conversion and Management, vol. 130, pp. 91–105, 2016.
  40. M. A. Kurniawan, D. Yuvenda, and B. Sudarmanta, “The Effects CNG Injection Timing on Engine Performance and Emissions of A Diesel Dual Fuel Engine,” IPTEK The Journal for Technology and Science, vol. 30, no. 2, pp. 64–67, 2019.
  41. J. da Silva, D. Yuvenda, and B. Sudarmanta, “Effects of Pilot Injection Timing on The Engine Performance of A Diesel Dual Fuel Engine,” IPTEK The Journal of Engineering, vol. 5, no. 2, 2019.
  42. J. Vávra, I. Bortel, M. Takáts, and M. Diviš, “Emissions and performance of diesel–natural gas dual-fuel engine operated with stoichiometric mixture,” Fuel, vol. 208, pp. 722–733, 2017.
  43. M. M. Abdelaal and A. H. Hegab, “Combustion and emission characteristics of a natural gas-fueled diesel engine with EGR,” Energy conversion and management, vol. 64, pp. 301–312, 2012.
  44. M. F. Mohd Nor, S. Hassan, Z. ZA, and M. MA, “Performance and Emission Characteristics of Supercharged Biomass Producer Gas-Diesel Dual Fuel Engine,” Journal of Applied Sciences, 2010.
  45. M. M. Abdelaal, B. A. Rabee, and A. H. Hegab, “Effect of adding oxygen to the intake air on a dual-fuel engine performance, emissions, and knock tendency,” Energy, vol. 61, pp. 612–620, 2013.
  46. S. V Khandal, N. R. Banapurmath, V. S. Yaliwal, G. Manavendra, and P. M. Akshay, “Effect of turbo charging on the performance of dual fuel (DF) engine operated on rice bran oil methyl ester (RBOME) and coconut shell derived producer gas induction,” J Pet Environ Biotechnol, vol. 6, no. 216, p. 2, 2015.
  47. C. Nayak and R. Swain, “Effect of turbocharger on the emission of a dual fuel diesel engine using producer gas and blends of karanja oil methyl ester,” Br J Renew Energy, vol. 1, pp. 46–51, 2016.
  48. D. Yuvenda, B. Sudarmanta, A. Wahjudi, and O. Muraza, “Improved combustion performances and lowered emissions of CNG-diesel dual fuel engine under low load by optimizing CNG injection parameters,” Fuel, vol. 269, no. November 2019, p. 117202, 2020, doi: 10.1016/j.fuel.2020.117202.
  49. B. Yang, L. Wang, L. Ning, and K. Zeng, “Effects of pilot injection timing on the combustion noise and particle emissions of a diesel/natural gas dual-fuel engine at low load,” Applied Thermal Engineering, vol. 102, pp. 822–828, 2016.
  50. D. Yuvenda, B. Sudarmanta, R. P. Putra, M. Martias, and E. Alwi, “Pengaruh Tekanan Injeksi Gas Terhadap Konsumsi Bahan Bakar dan Efisiensi Termal pada Mesin Diesel Dual Fuel,” INVOTEK: Jurnal Inovasi Vokasional dan Teknologi, vol. 19, no. 1, pp. 35–42, 2019.
  51. D. Y. Exoryanto, “Studi Eksperimen Unjuk Kerja Mesin Diesel Menggunakan Sistem Dual Fuel Solar-Gas CNG Dengan Variasi Tekanan Injection Gas Dan Derajat Waktu Injection.” Institut Teknologi Sepuluh Nopember, 2016.
  52. Z. Wisnu and B. Sudarmanta, “Studi Eksperimen Pengaruh Variasi Start Of Injection Dan Durasi Pemasukan Bahan Bakar Compressed Natural Gas Terhadap Performa Mesin Diesel Sistem Dual Fuel,” Institut Teknologi Sepuluh Nopember, 2015.
  53. J. You, Z. Liu, Z. Wang, D. Wang, and Y. Xu, “Impact of natural gas injection strategies on combustion and emissions of a dual fuel natural gas engine ignited with diesel at low loads,” Fuel, vol. 260, p. 116414, 2020.
  54. M. S. Acar and O. Arslan, “Exergo-economic Evaluation of a new drying system Boosted by Ranque-Hilsch vortex tube,” Applied Thermal Engineering, vol. 124, pp. 1–16, 2017.
  55. M. Ş. Acar, O. Erbaş, and O. Arslan, “The performance of vapor compression cooling system aided Ranque-Hilsch vortex tube,” 2019.
  56. J. Stewart, A. Clarke, and R. Chen, “An experimental study of the dual-fuel performance of a small compression ignition diesel engine operating with three gaseous fuels,” Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, vol. 221, no. 8, pp. 943–956, 2007.
  57. A. Sarkar and U. K. Saha, “Role of global fuel-air equivalence ratio and preheating on the behaviour of a biogas driven dual fuel diesel engine,” Fuel, vol. 232, pp. 743–754, 2018.
  58. J. Cho, S. Park, and S. Song, “The effects of the air-fuel ratio on a stationary diesel engine under dual-fuel conditions and multi-objective optimization,” Energy, vol. 187, p. 115884, 2019.
  59. J. Zheng, J. Wang, Z. Zhao, D. Wang, and Z. Huang, “Effect of equivalence ratio on combustion and emissions of a dual-fuel natural gas engine ignited with diesel,” Applied Thermal Engineering, vol. 146, pp. 738–751, 2019.
  60. E. Tomita, Y. Harada, N. Kawahara, and A. Sakane, “Effect of EGR on combustion and exhaust emissions in supercharged dual-fuel natural gas engine ignited with diesel fuel,” SAE Technical Papers, 2009.
  61. B. Yang, C. Xi, X. Wei, K. Zeng, and M.-C. Lai, “Parametric investigation of natural gas port injection and diesel pilot injection on the combustion and emissions of a turbocharged common rail dual-fuel engine at low load,” Applied Energy, vol. 143, pp. 130–137, 2015.
  62. J. Liu, F. Yang, H. Wang, M. Ouyang, and S. Hao, “Effects of pilot fuel quantity on the emissions characteristics of a CNG/diesel dual fuel engine with optimized pilot injection timing,” Applied Energy, vol. 110, no. x, pp. 201–206, 2013, doi: 10.1016/j.apenergy.2013.03.024.